|
| Author |
Message |
|
aspencer
|
Post subject: Aqualine cm-104  Posted: Sun Feb 22, 2009 1:50 pm |
Joined: Sun Feb 22, 2009 1:46 pm
Posts: 6
|
|
I have a GLS Sunlighter with a Brett Aqualine CM-104. In the last week it would try to start and click on and off then stay on. Now it starts and runs for about fifteen seconds and stops. Repeats about every five minutes. Will not start when the timer calls for it to. Any idea where to start with this thing? I replace the timer about two months ago and has been running fine. Any help is appreciated.
|
|
 |
|
 |
|
spishex
|
Post subject: Re: Aqualine cm-104 Posted: Mon Feb 23, 2009 8:46 am |
Joined: Mon Nov 03, 2008 8:12 am
Posts: 424
|
|
You mean the pump comes on every five minutes or the controls? Sounds like the motor is overheating.
_________________
1993 Hot Springs Classic
http://www.poolharmony.com
Pool and Spa Service in the Triangle, North Carolina
|
|
|
|
|
|
|
aspencer
|
Post subject: Re: Aqualine cm-104 Posted: Mon Feb 23, 2009 3:22 pm |
Joined: Sun Feb 22, 2009 1:46 pm
Posts: 6
|
|
Since my posting the pump motor is running fine when the timer calls for it to run. When the pump motor is off and the thermostat calls for the it to turn on it will turn on/off 3 to 4 times in very rapid succession and then finally stays on. Runs fine then shuts off after coming up to temp.
|
|
|
|
|
|
|
spishex
|
Post subject: Re: Aqualine cm-104 Posted: Mon Feb 23, 2009 6:11 pm |
Joined: Mon Nov 03, 2008 8:12 am
Posts: 424
|
|
Very rapid like a chattering (less than five seconds) or does it take longer than that?
_________________
1993 Hot Springs Classic
http://www.poolharmony.com
Pool and Spa Service in the Triangle, North Carolina
|
|
|
|
|
|
|
aspencer
|
Post subject: Re: Aqualine cm-104 Posted: Mon Feb 23, 2009 6:44 pm |
Joined: Sun Feb 22, 2009 1:46 pm
Posts: 6
|
|
Rapid chatter is very descriptive of it!
|
|
|
|
|
|
|
spishex
|
Post subject: Re: Aqualine cm-104 Posted: Mon Feb 23, 2009 8:13 pm |
Joined: Mon Nov 03, 2008 8:12 am
Posts: 424
|
|
Your thermostat is probably the culprit, since the same relay powers the pump on low for both situations.
_________________
1993 Hot Springs Classic
http://www.poolharmony.com
Pool and Spa Service in the Triangle, North Carolina
|
|
|
|
|
|
|
aspencer
|
Post subject: Re: Aqualine cm-104 Posted: Wed Feb 25, 2009 5:24 pm |
Joined: Sun Feb 22, 2009 1:46 pm
Posts: 6
|
|
Can you give me an idea of what I am looking for? I have located the pressure switch, the high limit switch, a compontent labeled Aquatemp, and the two Furnas motor starters.
|
|
|
|
|
|
|
spishex
|
Post subject: Re: Aqualine cm-104 Posted: Thu Feb 26, 2009 9:06 am |
Joined: Mon Nov 03, 2008 8:12 am
Posts: 424
|
|
It's a part of your topside control which is plugged in on the bottom left hand side of your pack.
_________________
1993 Hot Springs Classic
http://www.poolharmony.com
Pool and Spa Service in the Triangle, North Carolina
|
|
|
|
|
|
|
aspencer
|
Post subject: Re: Aqualine cm-104 Posted: Sun Mar 01, 2009 10:11 am |
Joined: Sun Feb 22, 2009 1:46 pm
Posts: 6
|
|
The top side control is a TDI Command Center (photo attached). I do not find anything like this on line. Is there an alternative?
|
|
|
|
|
|
|
ballmdr
|
Post subject: Re: Aqualine cm-104 Posted: Sun Mar 01, 2009 8:42 pm |
Joined: Sun Mar 01, 2009 8:36 pm
Posts: 1
|
|
|
|
|
|
|
|
